1、安裝要點

1. Installation points

彩鋼瓦的鋪放主要是看產品的長度，若是長度小于等于15M的屋面，建議采用重疊式，若是長度大于等于15M的屋面，則建議采用交錯式。彩鋼瓦專用釘一定要依照正確的方式安裝，將其打在瓦骨部位才能起到防水效用。專用釘要由瓦的下端往屋頂方向打同時固定間隔橫豎控制在50CM～100CM。屋頂側面用水泥密封后，再蓋上脊瓦；瓦的下部分使用專用釘固定，脊瓦交接的位置用玻璃膠密封；安裝接水材料，并做好防水工程。

The laying of color steel tiles mainly depends on the length of the product. If the length of the roof is less than or equal to 15M, it is recommended to use overlapping type. If the length of the roof is greater than or equal to 15M, it is recommended to use staggered type. The special nail for color steel tiles must be installed in the correct way and hit in the center of the tile bone to achieve waterproof effect. Special nails should be fixed from the lower end of the tile towards the roof, with a horizontal and vertical spacing controlled between 50CM and 100CM. After sealing the side of the roof with cement, cover it with ridge tiles; The lower part of the tile is fixed with dedicated nails, and the junction of the ridge tiles is sealed with glass glue; Install water connecting materials and carry out waterproofing work.

2、漏水修補

2. Leakage repair

使用割瓦機，在距離彩鋼瓦屋頂0.15m的混凝土墻上開一道溝，然后在溝內放入厚度在0.4到0.6mm的彩鋼板，再用拉鉚釘將彩鋼板的另一端固定在漏水屋頂上。固定的過程中，要將拉鉚釘固定好，以免出現拉鉚釘脫落的情況。漏水面積如果不大，當彩鋼房頂出現漏水的情況時，還可以使用組成高分子防水卷材和高分子防水涂料進行補漏，這些材料經過特殊加工，因此具有不錯的防水效果，用于彩鋼房頂補漏非常合適。

Firstly, use a tile cutting machine to create a trench on the concrete wall 0.15m away from the color steel tile roof. Then, place a color steel plate with a thickness of 0.4 to 0.6mm in the trench, and fix the other end of the color steel plate to the leaking roof with rivets. During the fixation process, the rivets should be securely fastened to prevent them from falling off. If the leakage area is not large, when there is a leakage on the color steel roof, polymer waterproof membranes and polymer waterproof coatings can be used to fill the leakage. These materials have been specially processed, so they have good waterproof effects and are very suitable for filling the leakage on the color steel roof.